Coloured Cotton From India Set For Commercial Release In 2021

0
259

After over three decades of research, an Indian variety of coloured cotton may be commercially released in 2021. A decision will be taken once the last phase of the agronomy trials is over this year, according to A.H. Prakash, project coordinator of the Indian Council for Agricultural Research-All India Coordinated Research Project on Cotton (ICAR-AICRP).

The final stage of the trials will end by April 2021 and a few promising seeds will be proposed for commercial release by a committee chaired by the deputy director-general of crop science, ICAR. While the University of Agricultural Sciences (UAS), Dharwad, and the ICAR-Central Institute for Cotton Research (CICR), Nagpur, have been engaged in sustained research and developed varieties of naturally-coloured cotton, a commercial release has been stalled on the pretext that it can contaminate white cotton. However, there is a boost from the current government and the ICAR for coloured cotton since 2017, when its field trials were included in the AICRP.

According to A.H. Prakash, “The Gossypium arboreum (desi) coloured cotton as such is not spinnable (by machines). It is only the colour gene that the scientists are transferring through conventional breeding to cultivated species to improve the quality, colour, stability and yield. The wild cottons also are shy bearers (low yielding) and crossing them with the stabilised cultivated cotton improves their yield,” he explained.

Under the AICRP, four to five coloured cotton lines (seeds under pre-release trials) are showing promise. They have been evaluated for abiotic/biotic stress, diseases, water requirement, stability, colour and yield. They are good yielders at an average of 10 to 15 quintals a hectare (one quintal equals 100 kg) and their fibre strength is being tested by the Central Institute for Research on Cotton Technology (CIRCOT), Mumbai. Since the coloured cottons being developed are varieties, farmers can reuse the seeds each year, he added.

To begin with, the AIRCP will recommend coloured cotton cultivation in niche areas or isolated places, which have a provision for separate ginning and processing. State governments are expected to manage this once the seed is commercially released, Prakash said. Each University can also tie-up with farmers or processing units for cultivation, weaving and manufacturing.

Also Read  Indian Spinning Industry – A “Black Hole” For Indian Cotton

Coloured cotton in Australia, China and the USA
Recently, an important breakthrough was achieved in Australia, and its two billion dollar cotton industry is anxiously awaiting new research by the Commonwealth Scientific and Industrial Research Organisation (CSIRO) scientists. The plant breeders here have genetically modified cotton to create coloured cotton in black and other rich, dark colours which could become a “game changer” in the years to come.

Since the 1980s, California-based Sally Fox has made brown cotton famous the world over. China is already a leader in coloured cotton.

Fox has spent 40 years commercialising coloured cotton in the USA. She began breeding these cottons in 1982 with the hope of improving the spinnability of the fibres so that they could be used commercially. “Everyone said that it could not be done. But I did it. Colored cotton has great potential. I do get the satisfaction of knowing that my life’s work is finally being taken seriously somewhere,” she said.

In India, about 40 coloured genotypes of upland cotton (G. hirsutum), mostly of various shades of brown and green colour are available in the National Gene Bank of Cotton maintained at the CICR. These genetic stocks are indigenous collections as well as exotic accessions from the USA, erstwhile USSR, Israel, Peru, Mexico, Egypt, etc. In Asiatic diploid cottons (G. arboreum and G. herbaceum) about 10 germplasm lines possessing mostly light brown lint colour are also available.

India had coloured cotton all along
According to the CICR, three coloured cotton varieties – Cocanda and two Red Northerns – were released for commercial cultivation in parts of Andhra Pradesh in the mid-1900s but work on coloured cotton was discontinued due to low yield and poor fibre properties. Now, this is the focus since the 1990s and research in coloured cotton was in full swing in about 10 agricultural universities in south and central India. They were using material from ICAR-CICR and the agricultural universities of Dharwad, Raichur, Surat, Nanded, Akola and Khandwa. The colours are a gradation from green to dark brown, and there are four to five distinctive colours, Prakash said.

Also Read  Well Covered Mills Wait For New Cotton Season, Prices Under Pressure

Brown cotton lines from UAS, Dharwad are at the forefront in the AICRP trials, said Rajesh Patil, principal scientist, University of Agricultural Sciences (UAS), Dharwad. He expects that one of its varieties, DDCC-1, will be proposed for release in 2021. UAS Dharwad has nine other colour genotypes which are also doing well, he added.

Much credit for this research goes to Manjula Maralappanavar, who worked from 1996 to 2014 as a cotton breeder, and is now senior breeder at the UAS, Dharwad. She has published papers on her research and had developed  DMB-225, a medium brown variety in 2013, along with three other varieties and also worked on DDCC-1.

DMB-225 was not released commercially on the grounds that it would contaminate white cotton, though its fibre quality was found highly suitable by the UAS textile department for machine spinning in 2010- 12. She has submitted DMB -225 for field trials during 2020-21 and she continues to improve upon the seeds.

In 2002, UAS Dharwad did have a limited commercial release of DDCC-1, an almond-coloured cotton variety, and 25 farmers cultivated it in Uppinbatigeri village. The Khadi and Village Industries Board of Karnataka had a nearby unit, which wove the cotton and made shirts out of it, in a unique collaboration that did not last due to lack of funding. The research was sponsored by the Cotton Corporation of India (CCI).

Another scientist at the forefront of coloured cotton research is Vinita Gotmare, principal scientist, ICAR-CICR Nagpur. Gotmare works on the conservation and use of the hardy and resistant wild species of cotton which are not indigenous to India. In the course of her research, she perfected a new genetic stock – Vaidehi 95 or MSH 53, and for the first time two wild species of cotton namely, G. raimondii and G.thurberi, were introgressed with G. hirsutum  and G.barbadense. She has been working to improve its fibre properties.

Also Read  Active Delayed Monsoon Can Stabilise Cotton Prices Ahead

Shades of brown more stable
Among coloured cotton genotypes, shades of brown are more stable than green genotypes which tend to fade when exposed to the sun. Gotmare said that Vaidehi 95 has good yield levels (17 to 18 quintals per hectare) and strong fibre properties and was tolerant to sucking pests and the pink bollworm.  Prakash confirmed that Vaidehi 95, with its dark brown colour, was one of the promising lines in the AICRP trials.

In fact, the lint from Vaidehi 95 was sent to Gopuri ashram at Wardha, two years ago, to hand spin and weave cloth. In addition, CIRCOT Mumbai took up the task of testing the machine spinning of this cotton. CICR now has a tripartite agreement with the Punjabrao Krishi Vidyapeeth, Akola and CIRCOT for large-scale seed production and value addition. CIRCOT will support entrepreneurs to develop novel textile products through its incubation centre.

Fear of coloured cotton contaminating white has been deplored by scientists like K.R. Kranthi, former director CICR, and now Technical Head, International Cotton Advisory Committee, USA. “Unfortunately, some scientists have been stalling all attempts to go ahead with an excuse that coloured cotton contaminates white cotton. This argument has no merit whatsoever in a country like India where seed production is regulated.”

Meanwhile, according to Patil, the Government of India was in the process of finalising a pilot project on coloured cotton involving agricultural universities, cotton and textile research bodies, farmers’ cooperative societies, the Khadi and Village Industries Commission, National Textile Corporation Ltd. and the textile industry.

LEAVE A REPLY

Please enter your comment!
Please enter your name here